Certain engines with overhead camshafts have timing belts that have a limited lifespan. Car makers use these belts instead of more durable chains because chains are noisier andcost more to manufacture. Your vehicle owner's manual will recommend at what mileage the timing belt must be replaced. These intervals range from every 60,000 miles to every 105,000 miles. To see what is recommended for your engine, click on the link at the bottom of this article.
The job of the timing belt is to turn the camshaft(s) at exactly 1/2 the speed of the crankshaft while maintaining a precise alignment. This means that the crankshaft will make two revolutions for every revolution of the camshaft. Engines will have at least one camshaft, or as many as four camshafts in some of the V-type engines. The camshaft causes the intake and exhaust valves to open and close in time with the pistons which move up and down in the cylinders. The valves must open and close at exactly the right time in relationship to the piston movement in order for the engine to run properly. For more information on how this works, go to "A Short Course on Engines" (Article Continues below)
There are two types of engines that use timing belts. They are described as: "Interference Engines" and "Non-interference Engines" The difference lies in the proximity between the valves and the pistons. On an interference engine, if the timing belt slips even one notch, the piston can crash into an open valve causing serious engine damage by bending valves and breaking pistons. Non-interference engines will usually not self destruct, but in either case if the belt fails, the engine will immediately shut down leaving you stranded. The link at the bottom of this article will tell you which category your engine falls under.
Timing belts fail without warning and on some vehicles, are almost as hard to check as they are to change. In most cases, your only protection is to change the belt at the recommended intervals. Timing belt replacement is not a cheap job but it is far less costly than the alternative.
Some technicians may recommend that you replace the water pump during atiming belt job even if there is nothing wrong with it. This is because90% of the labor to change the water pump has already been done with the timingbelt job and some technicians consider it good insurance to replace the pump atthis time. My feeling is that some water pumps can last the life of thecar but many do fail and will cost big money to replace at a later date. So ask your technician what his experience is with the water pump on your modelcar and look at how long you plan to keep the car. This way, at least you willbe making an informed roll of the dice.